欢迎来到天天文库
浏览记录
ID:52129601
大小:1.05 MB
页数:5页
时间:2020-03-23
《碱渣用作矿物掺合料对混凝土性能影响的试验研究.pdf》由会员上传分享,免费在线阅读,更多相关内容在行业资料-天天文库。
1、2017年第9期(总第335期)混凝土原材料及辅助物料Number9in2017(TotalNo.335)ConcreteMATERIALANDADMINICLEdoi:10.3969/j.issn.1002-3550.2017.09.021碱渣用作矿物掺合料对混凝土性能影响的试验研究杨医博a,b,普永强a,严卫军a,郭文瑛a,王恒昌a(华南理工大学a.土木与交通学院;b.亚热带建筑科学国家重点实验室,广东广州510640)摘要:碱渣是氨碱法制纯碱排出的废渣,由于含有大量的可溶性氯离子,碱渣直接用作混凝土掺合料时,会导致钢筋锈蚀,从而大大降低建筑物的
2、使用寿命。为解决碱渣应用的难题,对原状碱渣采用工艺处理得到不同氯离子含量的水洗碱渣和除氯碱渣,研究了三种碱渣对混凝土性能的影响。结果表明,碱渣掺入会严重降低混凝土的工作性能,但可以通过增加减水剂掺量的方式调节;在碱渣掺量为10%时,用碱渣等量取代粉煤灰或水泥时混凝土强度均略有增大;较高氯离子含量的原状碱渣和水洗碱渣均会造成钢筋锈蚀,只有氯离子含量低于0.30%的除氯碱渣可作为混凝土矿物掺合料使用,且无需掺加阻锈剂。关键词:碱渣;矿物掺合料;混凝土;耐久性中图分类号:TU528.041文献标志码:A文章编号:1002-3550(2017)09-0080
3、-04ExperimentalstudyontheperformanceofconcreteusingsodaresidueasmineraladmixtureYANGYiboa,b,PUYongqianga,YANWeijuna,GUOWenyinga,WANGHengchanga(a.SchoolofCivilEngineeringandTransportation;b.StateKeyLaboratoryofSubtropicalArchitecturesScience,SouthChinaUniversityofTechnology,Guan
4、gzhou510640,China)Abstract:Sodaresidueisthewasteofammoniasodaprocessproducingthesodaash.Becauseitcontainsalargeamountofsolublechlo-rideions,itcancausesteelcorrosionwhendirectlyappliedtoconcreteasadmixture,thusgreatlyreducingthelifeofthebuilding.Tosolvetheproblemofsodaresidueapp
5、lications,throughtheprocessfororiginalsodaresidue,getthewashingsodaresidueanddechlorinationso-daresiduewithlowchloridecontent,andstudytheeffectofthethreekindsofresidueonconcreteperformance.Theresultsshowthattheincorporationofsodaresiduewouldseriouslyreducetheperformanceofconcre
6、te,butcanbeadjustedbyaddingsuperplasticizer.Whenthecontentofsodaresidueis10%toreplacethesameamountofflyashorcement,theconcretestrengthbothwillincreaseslightly.Theorigi-nalsodaresidueandwashingsodaresiduewithhighchlorideioncontentwillcausesteelcorrosion,onlythedechlorinationsoda
7、residuewhichchloridecontentoflessthan0.30%canbeusedasmineraladmixtures,withoutaddingrustinhibitor.Keywords:sodaresidue;mineraladmixture;concrete;durability规范GB/T50476—2008《混凝土结构耐久性设计规范》[4]0引言规定,I-A环境下的混凝土胶凝材料氯离子限值为0.3%。天碱渣,又称白泥,是氨碱法制纯碱过程中产生的废渣,然碱渣中可溶性氯离子含量为10%左右(占干基质量),为满对于碱渣的处
8、理,通常采取堆积或填海的方式,其堆存和足以上规范规定的氯离子限值,碱渣应用于混凝土时,掺量排放已造成严重的资
此文档下载收益归作者所有